2004 Honda Pilot Fuel/Propulsion System Problems
- 9
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- fuel tank · 5 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 4 |
| 100–150k mi | 1 |
| 150–400k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel/Propulsion System
Fuel tank will not accept fuel in a timely matter, acts as though there is a plug in the tank.
ODI 11185859
Fuel/Propulsion System
Fuel tank-- the fuel tank will not fill at a normal rate, it continues to shut off as if the tank is full. Very annoying as it takes lots of time to fill the tank please advise [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).' *pm
ODI 11182430
Fuel/Propulsion System
Gasoline suddenly began leaking from fuel lines under the passenger side rear seat area. The vehicle was parked with the engine off when this happened and spilled liquid gasoline and fumes in my under house garage. The gasoline odors got into my basement and first floor living space.
ODI 10981432
Engine · Fuel/Propulsion System
Hello. After smelling gasoline type fumes off for some time (no one else in the family could smell it) and after consulting the honda pilot forums, i decided to replace the factory ngk pzfr5f-11 spark plugs at 99,430, rather than the honda recommended 105,000 miles. I was surprised to discover that the middle rear plug was only finger tight and as a result combustion gases were escaping between the plug and the…
ODI 10715355
Fuel/Propulsion System · Vehicle Speed Control
When we step on the gas pedal, it sticks, when you press down a little more, the car lurches quickly, causing a dangerous sudden acceleration. The worst is when we back out of our garage (we have an uphill driveway), but it happens in forward from a stop also... *tr
ODI 10678885
Fuel/Propulsion System
2004 pilot came standard with 19 gallon tank, and would start filling to overflow at nearly 22 gallons. This has happened several times with the tank either taking in excess of 20 gallons or not taking more than 0.75 gallons before stopping automatically. The tank then has to be slowly fed for nearly 25 minutes to get 16 gallons into the tank. *tr
ODI 10574071
Fuel/Propulsion System
Unable to refuel vehicle. Fuel pump shuts off after 3/4 gallon when filling. Dealer replaced orvr valve, but fix did not work. Yesterday i was able to pump about 2.5 gallons, but gas began spilling out of the tank. *tr
ODI 10508506
Fuel/Propulsion System
Often during refueling of my vehicle the gas pump shuts off after a few moments of refueling. At times, the gasoline backs up in the tube and spews back out onto the vehicle and the ground despite having a near empty fuel tank . It has become necessary to squeeze the pump handle lightly and trickle the gasoline into the fuel tank. I have also found this to occur at different gas stations as well. Thank you for your…
ODI 10481068
Fuel/Propulsion System · Power Train · Steering
The shift interlock allowed the key to be removed without the pilot being in park. This caused the pilot to roll backwards in a parking lot. Luckily the lot was fairly flat, so it didn't roll far or hit anything (or anybody!). A honda dealer confirmed the issue, and contacted honda about it. Honda said they wouldn't fix the issue due to the mileage, and the fact that i purchased the vehicle used (from carmax). *tr
ODI 10479494